Microwater droplet splitting and merging in a parallel-plate electrowetting-on-dielectric (EWOD) device have been studied numerically. The transient governing equations for the microfluidic flow are solved by a finite volume scheme with a two-step projection method on a fixed computational domain. The interface between liquid and gas is tracked by a coupled level set (LS) and volume-of-fluid (CLSVOF) method. A continuum surface force (CSF) model is employed to model the surface tension at the interface. Contact angle hysteresis which is an essential component in EWOD modeling is implemented together with a simplified model for the viscous stresses exerted by the two plates at the solid–liquid interface. The results of the numerical model have been validated with published experimental data and the physics of droplet motion within the EWOD device has been examined. A parametric study has been performed in which the effects of channel height and several other parameters on the fluid motion have been studied.
Issue Section:
Research Papers
References
1.
Madou
, M. J.
, 2002
, Fundamentals of Microfabrication: The Science of Miniaturization
, CRC Press
, Boca Raton, FL
.2.
Darhuber
, A. A.
, Davis
, J. M.
, Troian
, S. M.
, and Reisner
, W. W.
, 2003
, “Thermocapillary Actuation of Liquid Flow on Chemically Patterned Surfaces
,” Phys. Fluids
, 15
(5
), pp. 1295
–1304
.10.1063/1.15626283.
Lee
, J.
, He
, B.
, and Patankar
, N. A.
, 2005
, “A Roughness-Based Wettability Switching Membrane Device for Hydrophobic Surfaces
,” J. Micromech. Microeng.
, 15
(3
), pp. 591
–600
.10.1088/0960-1317/15/3/0224.
Lippmann
, G.
, 1875
, “Relations Entre Les Phénomènes Électriques et Capillaires
,” Ph.D. thesis, Gauthier-Villars
, Paris, France
.5.
Klingner
, A.
, and Mugele
, F.
, 2004
, “Electrowetting-Induced Morphological Transitions of Fluid Microstructures
,” J. Appl. Phys.
, 95
(5
), pp. 2918
–2920
.10.1063/1.16437716.
Mugele
, F.
, and Baret
, J.-C.
, 2005
, “Electrowetting: From Basics to Applications
,” J. Phys.: Condens. Matter
, 17
(28
), pp. R705
–R774
.10.1088/0953-8984/17/28/R017.
Darhuber
, A. A.
, and Troian
, S. M.
, 2005
, “Principles of Microfluidic Actuation by Modulation of Surface Stresses
,” Annu. Rev. Fluid Mech.
, 37
(1
), pp. 425
–455
.10.1146/annurev.fluid.36.050802.1220528.
Minnema
, L.
, Barneveld
, H.
, and Rinkel
, P.
, 1980
, “An Investigation into the Mechanism of Water Treeing in Polyethylene High-Voltage Cables
,” IEEE Trans. Electr. Insul.
, 6
, pp. 461
–472
.10.1109/TEI.1980.2982759.
Berge
, B.
, 1993
, “Electrocapillarité et Mouillage de Films Isolants par l'eau
,” C. R. Acad. Sci. Sér. 2, Méc., Phys., Chim., Sci. Terre Univers
, 317
(2
), pp. 157
–163
.10.
Pollack
, M. G.
, Shenderov
, A. D.
, and Fair
, R. B.
, 2002
, “Electrowetting-Based Actuation of Droplets for Integrated Microfluidics
,” Lab Chip
, 2
(2
), pp. 96
–101
.10.1039/b110474h11.
Cho
, S. K.
, Moon
, H.
, and Kim
, C.-J.
, 2003
, “Creating, Transporting, Cutting, and Merging Liquid Droplets by Electrowetting-Based Actuation for Digital Microfluidic Circuits
,” J. Microelectromech. Syst.
, 12
(1
), pp. 70
–80
.10.1109/JMEMS.2002.80746712.
Jang
, L. S.
, Lin
, G. H.
, Lin
, Y. L.
, Hsu
, C. Y.
, Kan
, W. H.
, and Chen
, C. H.
, 2007
, “Simulation and Experimentation of a Microfluidic Device Based on Electrowetting on Dielectric
,” Biomed. Microdevices
, 9
(6
), pp. 777
–786
.10.1007/s10544-007-9089-813.
Walker
, S. W.
, and Shapiro
, B.
, 2006
, “Modeling the Fluid Dynamics of Electrowetting on Dielectric (EWOD)
,” J. Microelectromech. Syst.
, 15
(4
), pp. 986
–1000
.10.1109/JMEMS.2006.87887614.
Walker
, S. W.
, Shapiro
, B.
, and Nochetto
, R. H.
, 2009
, “Electrowetting With Contact Line Pinning: Computational Modeling and Comparisons With Experiments
,” Phys. Fluids
, 21
(10
), p. 102103
.10.1063/1.325402215.
Wang
, K.-L.
, and Jones
, T.
, 2005
, “Electrowetting Dynamics of Microfluidic Actuation
,” Langmuir
, 21
(9
), pp. 4211
–4217
.10.1021/la046870216.
Decamps
, C.
, and De Coninck
, J.
, 2000
, “Dynamics of Spontaneous Spreading Under Electrowetting Conditions
,” Langmuir
, 16
(26
), pp. 10150
–10153
.10.1021/la000590e17.
Oh
, J. M.
, Ko
, S. H.
, and Kang
, K. H.
, 2010
, “Analysis of Electrowetting-Driven Spreading of a Drop in Air
,” Phys. Fluids
, 22
(3
), p. 032002
.10.1063/1.336033118.
Hoshino
, K.
, Triteyaprasert
, S.
, Matsumoto
, K.
, and Shimoyama
, I.
, 2004
, “Electrowetting-Based Pico-Liter Liquid Actuation in a Glass-Tube Microinjector
,” Sens. Actuators, A
, 114
(2
), pp. 473
–477
.10.1016/j.sna.2004.02.00219.
Wheeler
, A. R.
, Moon
, H.
, Kim
, C.-J.
, Loo
, J. A.
, and Garrell
, R. L.
, 2004
, “Electrowetting-Based Microfluidics for Analysis of Peptides and Proteins by Matrix-Assisted Laser Desorption/Ionization Mass Spectrometry
,” Anal. Chem.
, 76
(16
), pp. 4833
–4838
.10.1021/ac049811220.
Matsumoto
, H.
, and Colgate
, J. E.
, 1990
, “Preliminary Investigation of Micropumping Based on Electrical Control of Interfacial Tension
,” IEEE
Micro Electro Mechanical Systems. An Investigation of Micro Structures
, Sensors, Actuators, Machines and Robots
, IEEE
, pp. 105
–110
.10.1109/MEMSYS.1990.11025821.
Batchelor
, G. K.
, 2000
, An Introduction to Fluid Dynamics
, Cambridge University Press
, Cambridge, UK.22.
Hirt
, C. W.
, and Nichols
, B. D.
, 1981
, “Volume of Fluid (VOF) Method for the Dynamics of Free Boundaries
,” J. Comput. Phys.
, 39
(1
), pp. 201
–225
.10.1016/0021-9991(81)90145-523.
Rudman
, M.
, 1998
, “A Volume-Tracking Method for Incompressible Multifluid Flows With Large Density Variations
,” Int. J. Numer. Methods Fluids
, 28
(2
), pp. 357
–378
.10.1002/(SICI)1097-0363(19980815)28:2<357::AID-FLD750>3.0.CO;2-D24.
Sussman
, M.
, Smereka
, P.
, and Osher
, S.
, 1994
, “A Level Set Approach for Computing Solutions to Incompressible Two-Phase Flow
,” J. Comput. Phys.
, 114
(1
), pp. 146
–159
.10.1006/jcph.1994.115525.
Scardovelli
, R.
, and Zaleski
, S.
, 1999
, “Direct Numerical Simulation of Free-Surface and Interfacial Flow
,” Annu. Rev. Fluid Mech.
, 31
(1
), pp. 567
–603
.10.1146/annurev.fluid.31.1.56726.
Meier
, M.
, Yadigaroglu
, G.
, and Smith
, B. L.
, 2002
, “A Novel Technique for Including Surface Tension in PLIC-VOF Methods
,” Eur. J. Mech.-B/Fluids
, 21
(1
), pp. 61
–73
.10.1016/S0997-7546(01)01161-X27.
Renardy
, Y.
, and Renardy
, M.
, 2002
, “PROST: A Parabolic Reconstruction of Surface Tension for the Volume-of-Fluid Method
,” J. Comput. Phys.
, 183
(2
), pp. 400
–421
.10.1006/jcph.2002.719028.
Tong
, A. Y.
, and Wang
, Z.
, 2007
, “A Numerical Method for Capillarity-Dominant Free Surface Flows
,” J. Comput. Phys.
, 221
(2
), pp. 506
–523
.10.1016/j.jcp.2006.06.03429.
Sussman
, M.
, and Puckett
, E. G.
, 2000
, “A Coupled Level Set and Volume-of-Fluid Method for Computing 3D and Axisymmetric Incompressible Two-Phase Flows
,” J. Comput. Phys.
, 162
(2
), pp. 301
–337
.10.1006/jcph.2000.653730.
Son
, G.
, and Hur
, N.
, 2002
, “A Coupled Level Set and Volume-of-Fluid Method for the Buoyancy-Driven Motion of Fluid Particles
,” Numer. Heat Transfer, Part B
, 42
(6
), pp. 523
–542
.10.1080/1040779026044480431.
Sussman
, M.
, 2003
, “A Second Order Coupled Level Set and Volume-of-Fluid Method for Computing Growth and Collapse of Vapor Bubbles
,” J. Comput. Phys.
, 187
(1
), pp. 110
–136
.10.1016/S0021-9991(03)00087-132.
Yang
, X.
, James
, A. J.
, Lowengrub
, J.
, Zheng
, X.
, and Cristini
, V.
, 2006
, “An Adaptive Coupled Level-Set/Volume-of-Fluid Interface Capturing Method for Unstructured Triangular Grids
,” J. Comput. Phys.
, 217
(2
), pp. 364
–394
.10.1016/j.jcp.2006.01.00733.
Rudman
, M.
, 1997
, “Volume-Tracking Methods for Interfacial Flow Calculations
,” Int. J. Numer. Methods Fluids
, 24
(7
), pp. 671
–691
.10.1002/(SICI)1097-0363(19970415)24:7<671::AID-FLD508>3.0.CO;2-934.
Wang
, Z.
, and Tong
, A. Y.
, 2010
, “A Sharp Surface Tension Modeling Method for Two-Phase Incompressible Interfacial Flows
,” Int. J. Numer. Methods Fluids
, 64
(7
), pp. 709
–732
.10.1002/fld.216635.
Brackbill
, J.
, Kothe
, D. B.
, and Zemach
, C.
, 1992
, “A Continuum Method for Modeling Surface Tension
,” J. Comput. Phys.
, 100
(2
), pp. 335
–354
.10.1016/0021-9991(92)90240-Y36.
Gupta
, R.
, Sheth
, D. M.
, Boone
, T. K.
, Sevilla
, A. B.
, and Frechette
, J.
, 2011
, “Impact of Pinning of the Triple Contact Line on Electrowetting Performance
,” Langmuir
, 27
(24
), pp. 14923
–14929
.10.1021/la203320g37.
Keshavarz-Motamed
, Z.
, Kadem
, L.
, and Dolatabadi
, A.
, 2009
, “Effects of Dynamic Contact Angle on Numerical Modeling of Electrowetting in Parallel Plate Microchannels
,” Microfluid. Nanofluid.
, 8
(1
), pp. 47
–56
.10.1007/s10404-009-0460-338.
Harlow
, F.
, and Amsden
, A.
, 1971
, “Fluid Dynamics: A LASL Monograph (Mathematical Solutions for Problems in Fluid Dynamics)
,” Los Alamos National Laboratory, Technical Report No. LA-4700.39.
Kothe
, D. B.
, Mjolsness
, R. C.
, and Torrey
, M. D.
, 1991
, “RIPPLE: A Computer Program for Incompressible Flows With Free Surfaces
,” Los Alamos National Laboratory, Technical Report No. LA-12007-MS.Copyright © 2015 by ASME
You do not currently have access to this content.
