This paper proposes advancement in the fault diagnosis of induction motors (IMs) based on the wavelet packet transform (WPT) and the support vector machine (SVM). The aim of this work is to develop and perform the fault diagnosis of IMs at intermediate operating conditions (i.e., the speed and the load) to take care of situations where the data are limited or difficult to obtain at required speeds and loads. In order to check the capability of proposed fault diagnosis, ten different IM fault (mechanical and electrical) conditions are considered simultaneously. In order to obtain the useful information from raw time series data that can characterize each of the fault classes at various operating conditions, the wavelet packet is applied to decompose the data of vibration and current signals from the experimental test rig. Fault features are then obtained using the decomposed data and further used for the diagnosis. In this work, five different wavelet functions (i.e., the Haar, Daubechies, Symlet, Coiflet, and Discrete Meyer) are considered in order to analyze the impact of different wavelets on the IM fault diagnosis. The proposed fault diagnosis has been initially attempted for the same speed and load cases and then extended innovatively to the intermediate speed and load cases. In order to check the robustness of the proposed methodology, the diagnosis is performed for a wide range of motor operating conditions. The results show the feasibility of the proposed fault diagnosis for the successful detection and isolation of various faults of IM, even with limited data or information at some motor operating conditions.

References

1.
Nandi
,
S.
,
Toliyat
,
H. A.
, and
Li
,
X.
,
2005
, “
Condition Monitoring and Fault Diagnosis of Electrical Motors—A Review
,”
IEEE Trans. Energy Convers.
,
20
(
4
), pp.
719
729
.
2.
Zhang
,
P.
,
Du
,
Y.
,
Habetler
,
T. G.
, and
Lu
,
B.
,
2011
, “
A Survey of Condition Monitoring and Protection Methods for Medium-Voltage Induction Motors
,”
IEEE Trans. Ind. Appl.
,
47
(
1
), pp.
34
46
.
3.
Singh
,
G. K.
,
2003
, “
Induction Machine Drive Condition Monitoring and Diagnostic Research—A Survey
,”
Electric Power Syst. Res.
,
64
(
2
), pp.
145
158
.
4.
Alsaedi
,
M. A.
,
2015
, “
Fault Diagnosis of Three-Phase Induction Motor: A Review
,”
Appl. Optics Signal Proc.
,
4
(
1
), pp.
1
8
.
5.
Gangsar
,
P.
, and
Tiwari
,
R.
,
2016
, “
Taxonomy of Induction-Motor Mechanical-Fault Based on Time-Domain Vibration Signals by Multiclass SVM Classifiers
,”
Intell. Ind. Syst.
,
2
(
3
), pp.
269
281
.
6.
Chang
,
S. C.
, and
Yacamini
,
R.
,
1996
, “
Experimental Study of the Vibrational Behaviour of Machine Stators
,”
IEE Proc. Electric Power Appl.
,
143
(
3
), pp.
242
250
.
7.
Maruthi
,
G. S.
, and
Vittal
,
K. P.
,
2005
, “
Electrical Fault Detection in Three Phase Squirrel Cage Induction Motor by Vibration Analysis Using MEMS Accelerometer
,”
International Conference on Power Electronics and Drives Systems
(
PEDS
), Kuala Lumpur, Malaysia, Nov. 28–Dec. 1, pp.
838
843
.
8.
Da Silva
,
A. M.
,
Povinelli
,
R. J.
, and
Demerdash
,
N. A.
,
2008
, “
Induction Machine Broken Bar and Stator Short-Circuit Fault Diagnostics Based on Three-Phase Stator Current Envelopes
,”
IEEE Trans. Ind. Electron.
,
55
(
3
), pp.
1310
1318
.
9.
Benbouzid
,
M. E. H.
,
Vieira
,
M.
, and
Theys
,
C.
,
1999
, “
Induction Motors' Faults Detection and Localization Using Stator Current Advanced Signal Processing Techniques
,”
IEEE Trans. Power Electron.
,
14
(
1
), pp.
14
22
.
10.
Thomson
,
W. T.
, and
Orpin
,
P.
,
2002
, “
Current and Vibration Monitoring for Fault Diagnosis and Root Cause Analysis of Induction Motor Drives
,”
31st Turbomachinery Symposium,
College Station, TX, Sept., pp.
61
67
.https://pdfs.semanticscholar.org/d815/a65f12ea894f2f2b54187cf6d7d7ed7c8aeb.pdf
11.
Gangsar
,
P.
, and
Tiwari
,
R.
,
2017
, “
Comparative Investigation of Vibration and Current Monitoring for Prediction of Mechanical and Electrical Faults in Induction Motor Based on Multiclass-Support Vector Machine Algorithms
,”
Mech. Syst. Signal Process.
,
94
, pp.
464
481
.
12.
Mehrjou
,
M. R.
,
Mariun
,
N.
,
Marhaban
,
M. H.
, and
Misron
,
N.
,
2011
, “
Rotor Fault Condition Monitoring Techniques for Squirrel-Cage Induction Machine-A Review
,”
Mech. Syst. Signal Process.
,
25
(
8
), pp.
2827
2848
.
13.
Peng
,
Z. K.
, and
Chu
,
F. L.
,
2004
, “
Application of the Wavelet Transform in Machine Condition Monitoring and Fault Diagnostics: A Review With Bibliography
,”
Mech. Syst. Signal Process.
,
18
(
2
), pp.
199
221
.
14.
Yan
,
R.
,
Gao
,
R. X.
, and
Chen
,
X.
,
2014
, “
Wavelets for Fault Diagnosis of Rotary Machines: A Review With Applications
,”
Signal Process.
,
96
(Pt. A), pp.
1
15
.
15.
Gao
,
R. X.
, and
Yan
,
R.
,
2006
, “
Non-Stationary Signal Processing for Bearing Health Monitoring
,”
Int. J. Manuf. Res.
,
1
(
1
), pp.
18
40
.
16.
Zarei
,
J.
, and
Poshtan
,
J.
,
2007
, “
Bearing Fault Detection Using Wavelet Packet Transform of Induction Motor Stator Current
,”
Tribol. Int.
,
40
(
5
), pp.
763
769
.
17.
Awadallah
,
M. A.
, and
Morcos
,
M. M.
,
2003
, “
Application of AI Tools in Fault Diagnosis of Electrical Machines and Drives-an Overview
,”
IEEE Trans. Energy Convers.
,
18
(
2
), pp.
245
251
.
18.
Rapur
,
J. S.
, and
Tiwari
,
R.
,
2017
, “
Experimental Time-Domain Vibration-Based Fault Diagnosis of Centrifugal Pumps Using Support Vector Machine
,”
ASCE-ASME J. Risk Uncertainty Eng. Syst., Part B
,
3
(
4
), p.
044501
.
19.
Yang
,
B. S.
,
Oh
,
M. S.
, and
Tan
,
A. C. C.
,
2009
, “
Fault Diagnosis of Induction Motor Based on Decision Trees and Adaptive Neuro-Fuzzy Inference
,”
Expert Syst. Appl.
,
36
(
2
), pp.
1840
1849
.
20.
Chattopadhyay
,
P.
, and
Konar
,
P.
,
2014
, “
Feature Extraction Using Wavelet Transform for Multi-Class Fault Detection of Induction Motor
,”
J. Inst. Eng. (India): Ser. B
, 95(1), pp.
73
81
.
21.
Yen
,
G. G.
, and
Lin
,
K. C.
,
2000
, “
Wavelet Packet Feature Extraction for Vibration Monitoring
,”
IEEE Trans. Ind. Electron.
,
47
(
3
), pp.
650
667
.
22.
Widodo
,
A.
, and
Yang
,
B. S.
,
2008
, “
Wavelet Support Vector Machine for Induction Machine Fault Diagnosis Based on Transient Current Signal
,”
Expert Syst. Appl.
,
35
(
1
), pp.
307
316
.
23.
Bordoloi
,
D. J.
, and
Tiwari
,
R.
,
2014
, “
Support Vector Machine Based Optimization of Multi-Fault Classification of Gears With Evolutionary Algorithms From Time–Frequency Vibration Data
,”
Measurement
,
55
, pp.
1
14
.
24.
Zhou
,
H.
,
Chen
,
J.
,
Dong
,
G.
, and
Wang
,
R.
,
2016
, “
Detection and Diagnosis of Bearing Faults Using Shift-Invariant Dictionary Learning and Hidden Markov Model
,”
Mech. Syst. Signal Process.
,
72–73
, pp.
65
79
.
25.
Samanta
,
B.
,
2004
, “
Gear Fault Detection Using Artificial Neural Networks and Support Vector Machines With Genetic Algorithms
,”
Mech. Syst. Signal Process.
,
18
(
3
), pp.
625
644
.
26.
Silva
,
V. A. D.
, and
Pederiva
,
R.
,
2013
, “
Fault Detection in Induction Motors Based on Artificial Intelligence
,”
International Conference on Surveillance 7
, Chartres, France, Oct. 29–30, pp.
1
15
.https://surveillance7.sciencesconf.org/conference/surveillance7/32_fault_detection_in_induction_motors_based_on_artificial_intelligence.pdf
27.
Ye
,
Z.
,
Wu
,
B.
, and
Sadeghian
,
A. R.
,
2001
, “
Induction Motor Mechanical Fault Online Diagnosis With the Application of Artificial Neural Network
,”
16th Annual IEEE Applied Power Electronics Conference and Exposition
(
APEC
2001), Anaheim, CA, Mar. 4–8, pp.
1015
1021
.
28.
Keskes
,
H.
,
Braham
,
A.
, and
Lachiri
,
Z.
,
2013
, “
Broken Rotor Bar Diagnosis in Induction Machines Through Stationary Wavelet Packet Transform and Multiclass Wavelet SVM
,”
Electric Power Syst. Res.
,
97
, pp.
151
157
.
29.
Keskes
,
H.
, and
Braham
,
A.
,
2014
, “
DAG SVM and Pitch Synchronous Wavelet Transform for Induction Motor Diagnosis
,”
Seventh IET International Conference on Power Electronics, Machines and Drives
(
PEMD
), Manchester, UK, Apr. 8–10, pp.
1
6
.
30.
Keskes
,
H.
, and
Braham
,
A.
,
2015
, “
Recursive Undecimated Wavelet Packet Transform and DAG SVM for Induction Motor Diagnosis
,”
IEEE Trans. Ind. Inf.
,
11
(
5
), pp.
1059
1066
.
31.
Zhang
,
L.
,
Xiong
,
G.
,
Liu
,
H.
,
Zou
,
H.
, and
Guo
,
W.
,
2010
, “
Fault Diagnosis Based on Optimized Node Entropy Using Lifting Wavelet Packet Transform and Genetic Algorithms
,”
Proc. Inst. Mech. Eng., Part I
,
224
(
5
), pp.
557
573
.
32.
Vapnik
,
V. N.
,
1999
, “
An Overview of Statistical Learning Theory
,”
IEEE Trans. Neural Networks
,
10
(
5
), pp.
988
999
.
33.
Burges
,
C. J.
,
1998
, “
A Tutorial on Support Vector Machines for Pattern Recognition
,”
Data Min. Knowl. Discovery
,
2
(
2
), pp.
121
167
.
34.
Hsu
,
C. W.
, and
Lin
,
C. J.
,
2002
, “
A Comparison of Methods for Multiclass Support Vector Machines
,”
IEEE Trans. Neural Networks
,
13
(
2
), pp.
415
425
.
35.
Chang
,
C. C.
, and
Lin
,
C. J.
,
2011
, “
LIBSVM: A Library for Support Vector Machines
,”
ACM Trans. Intell. Syst. Technol.
,
2
(
3
), pp.
27:1
27:27
.
36.
Coifman
,
R. R.
, and
Wickerhauser
,
M. V.
,
1992
, “
Entropy-Based Algorithms for Best Basis Selection
,”
IEEE Trans. Inf. Theory
,
38
(
2
), pp.
713
718
.
37.
Hu
,
X.
,
Wang
,
Z.
, and
Ren
,
X.
,
2005
, “
Classification of Surface EMG Signal Using Relative Wavelet Packet Energy
,”
Comput. Methods Programs Biomed.
,
79
(
3
), pp.
189
195
.
38.
Choi
,
S.
,
2008
, “
Detection of Valvular Heart Disorders Using Wavelet Packet Decomposition and Support Vector Machine
,”
Expert Syst. Appl.
,
35
(
4
), pp.
1679
1687
.
39.
Tiwari
,
R.
,
2017
,
Rotor Systems: Analysis and Identification
,
CRC Press
,
Boca Raton, FL
.
You do not currently have access to this content.